Air Duct Repair in Gresham - Tested First, Written Price Second

Trusted Air Duct Repair for Gresham Homeowners

Ducts that leak, sag, or pull apart at the seams waste the air you’re paying to heat, and in Gresham’s damp fall and winter the problem often announces itself as a cold room, a whistling register, or dust that collects on the same shelf no matter how often you wipe it down. We repair ducts, not just clean them, so a technician can find the failed joint or crushed run and correct it while the system is already open. Our technicians have up to 15 years of experience with residential ductwork, and we use professional-grade equipment from Rotobrush and Nikro rather than consumer gear. We can often reach Gresham homes the same day you call. Call (844) 523-1942 for a free estimate.

Call (844) 523-1942

HVAC Duct Installation

HVAC Duct Installation is the work of running a new duct system or extending an existing one to reach rooms it was never built to serve. You need it when a remodel adds square footage, when a converted garage or finished basement has no supply or return, or when an older layout was sized for equipment that’s no longer there. We plan the run, match duct sizing to the air handler’s capacity, and seal and support the trunk and branches so the system delivers what the equipment is rated for. Typical installation in Gresham runs $1,800-$6,500 depending on the number of runs and how much access the attic or crawlspace allows, and your written estimate sets the final price. Our technicians bring Rotobrush equipment to verify the new runs are clear before the system goes back into service.

Plan First, Then Cut

We map the existing trunk line, registers, and returns before anything is opened, because routing a new branch through a settled attic takes less work than rerouting one that was placed badly. Sizing comes from the air handler’s rated airflow, not from guesswork. That step is where most comfort complaints start.

Sealing the New Runs

Every joint on a new run gets sealed at the boot, the collar, and the plenum connection. Unsealed boots in an attic lose conditioned air straight into the insulation. We check the finished system with a pressure reading so the installation is verified, not assumed.

Air Duct Replacement

Air Duct Replacement means removing failed duct sections and installing new ones in their place, which becomes the sensible option when the old material is beyond patching. You’ll need it when flexible duct has collapsed inside a wall cavity, when the inner liner has torn away from the outer jacket, or when an older rigid system has been patched so many times the patches are holding the duct up. We pull the failed runs, check the plenum and register boots while everything is exposed, and install new ducting that’s sized and sealed to the current system. Typical air duct replacement in Gresham runs $600-$3,200 depending on how many runs are involved and how difficult the access is, with the written estimate setting the final price.

When Patching Stops Making Sense

A single torn joint is a repair. Three patches on one run usually means the material is finished and further patching just moves the leak. We tell you which one you’re looking at before any work begins.

Matching the Old System

Replacement runs have to match the original sizing or the room gets too little or too much air after the work is done. We measure the existing branches and the air handler’s capacity together. That’s where a replacement either fixes a room or creates a new complaint.

Ductwork Repair

Ductwork Repair covers the leaks, disconnected joints, crushed sections, and torn liners that let a system lose air before it ever reaches a register. It’s the right call when the ducts are structurally sound but failing at specific points: a boot pulled away from the floor, a flex run pinched behind a joist, a seam that’s opened in the attic. We locate the failure with airflow readings and a visual inspection of the accessible runs, then seal, re-support, or reconnect the section that’s failing. Typical ductwork repair in Gresham runs $180-$650 depending on how many problem points are found and how much attic or crawlspace work is involved, and the written estimate fixes the price before anyone starts.

Finding the Leak

Most duct leaks announce themselves through pressure loss, not visible damage. We compare register airflow room by room and inspect the accessible trunk and branches to find where the loss is happening. Chasing a comfort complaint without that step wastes everyone’s afternoon.

Sealing and Re-Supporting

Loose flex duct lying on its side in an attic compresses and chokes airflow just as effectively as a hole. We re-hang and re-support sagging runs as well as sealing the joints. A repaired run that’s still sagging will fail again.

Duct Replacement

Duct Replacement is the broader job of taking out an entire failed duct system and putting a new one in, which comes up when the original installation was undersized, badly routed, or made of material that’s reached the end of its life across the whole house. Signs include rooms that have never heated properly, ductwork that’s visibly deteriorated at every accessible point, or a system that’s been adapted through several rounds of equipment changes. We remove the old runs, plan a new layout that matches the current air handler, and install and seal it as one system. Typical duct replacement in Gresham runs $2,500-$8,000 depending on house size, duct type, and access, with the written estimate as the final word on price.

Judging Whether the Whole System Needs It

One bad run is a repair. Deterioration at every accessible point, chronic comfort problems in multiple rooms, and a layout that never matched the equipment usually point to replacement. We look at all three together before recommending it.

What Changes With New Ductwork

A properly planned replacement corrects routing shortcuts taken in the original build, such as long runs with too many turns or returns pulled from the wrong side of the house. Airflow balance improves because the layout is planned instead of inherited. Sealing is done at every joint, not just the visible ones.

Ductwork Installation

Ductwork Installation is the original work of putting a duct system into a home that doesn’t have one, or building out a system for new construction and additions. It applies to a new build, a shop or garage conversion being tied into the house system, or an addition that needs its own supply and return runs. We design the layout around the air handler’s rated capacity, install rigid or flexible ducting as the space allows, seal and insulate the runs, and check the finished system’s airflow before handing it back. Typical ductwork installation in Gresham runs $1,500-$5,500 depending on the number of runs and the access available, with the written estimate setting the final figure.

Layout and Sizing

Layout comes before material. The trunk and branch sizes are set from the air handler’s rated airflow, and register placement follows how each room is actually used. Getting this wrong at installation is expensive to correct later.

Insulation and Support

Ductwork in an unconditioned attic needs insulation rated for the temperature swing it will see, and support every few feet so it doesn’t sag between hangers. We install both as part of the job. Sagging duct loses capacity quietly over the first few winters.

Brands We Service

We work with filtration and abatement equipment from Aprilaire and Abatement Technologies, and we know how those systems are built and where they wear. Aprilaire filtration and humidity components sit inline with the ductwork, so repairing the duct around them means understanding how the cabinet and bypass are mounted. Abatement Technologies air filtration units are common in homes where someone’s been managing dust or allergy concerns, and their duct connections see more stress than a standard register run.

Rotobrush cleaning systems are the equipment we use on the duct side, and Guardsman components show up in ductwork we service around Gresham. Familiarity with these brands means fewer surprises when we open a system and find equipment we’ve seen before. Whether you have Aprilaire, Abatement Technologies, Guardsman, or any other make, we can help. One call covers cleaning, repair, and dryer vent safety, so you’re not coordinating three contractors for one house.

Signs You Need a Pro Right Now

• Whistling or roaring at a register. A register that’s louder than the others usually means a restriction or a disconnected joint upstream. The noise is the symptom, not the problem, and it gets worse as the restriction grows.
• Dust settling on the same surfaces. Dust that returns within a day or two of cleaning often points to a leak pulling air from an attic or crawlspace. Cleaning alone won’t fix it.
• Rooms that never heat or cool properly. One room consistently off from the rest usually means a crushed or disconnected run feeding it. Sealing and re-supporting that run often resolves it without touching the equipment.
• Visible sagging or torn duct in the attic. Flexible duct that’s come off its hangers, or has a torn outer jacket, is losing air and pulling in attic air at the same time. That’s a repair, not a cleaning.
• A sudden jump in energy bills. When a duct system starts leaking heavily, the equipment runs longer to make up for air that never arrives. A repair often pays for itself in a season or two.

Our Process, Step by Step

1. 1
   Phone consultation. We ask what you’re seeing and hearing so we arrive with the right equipment for the likely problem. We answer 24/7, with fast dispatch from 7am to 7pm, Sunday through Friday.
2. 2
   On-site inspection. The technician inspects the accessible trunk, branches, and registers, and takes airflow and pressure readings where the complaint warrants it. Nothing gets quoted off a phone description alone.
3. 3
   Written estimate. You get the findings in plain language and a flat price for the repair, agreed before any work starts. If the ducts turn out to be sound, we tell you that and you owe nothing for the estimate.
4. 4
   The repair. Sealing, reconnecting, re-supporting, or replacing failed sections happens on site. Our technicians have up to 15 years of experience with this work, and Rotobrush and Nikro equipment is on hand for the cleaning side of the job.
5. 5
   Verification and photos. We check airflow at the registers before and after, show you photos of the repair, and walk through what was done. If a follow-up visit is needed, it’s scheduled before we leave.

How Much Does Air Duct Repair Cost in Gresham?

Our Service Area Near Gresham

We serve homeowners throughout Gresham and the surrounding east Multnomah County area, including Fairview, Troutdale, Damascus, Sandy, and Gladstone, with coverage extending toward Oregon City, West Linn, Tigard, and Tualatin. Response times depend on the day and where you’re located, and we can often reach homes in the closer neighborhoods the same day you call. If you’re outside the immediate area, a call for duct cleaning gresham coverage for nearby towns is the fastest way to confirm.

Frequently Asked Questions About Air Duct Repair in Gresham

Schedule Your Air Duct Repair Service in Gresham Today

If your ducts are leaking, sagging, or failing in a room that’s never been comfortable, we can take a look and give you a written price for the fix. Our estimates are free and there’s no obligation. Call (844) 523-1942. We answer 24/7, with fast dispatch from 7am to 7pm, Sunday through Friday. One call covers Gresham cleaning, repair, and dryer vent safety.

Written by the team at Duct Cleaning Gresham.